Partager

Etude expérimentale de transfert de chaleur par condensation dans des minicanaux verticaux du nouveau frigorigène R1234ze(E) comparé au R134a et au R236fa.

Experimental study on condensation heat transfer in vertical minichannels for new refrigerant R1234ze(E) versus R134a and R236fa.

Auteurs : PARK J. E., VAKILI-FARAHANI F., CONSOLINI L., et al.

Type d'article : Article

Résumé

Experimental condensation heat transfer data for the new refrigerant R1234ze(E), trans-1,3,3,3-tetrafluoropropene, are presented and compared with refrigerants R134a and R236fa for a vertically aligned, aluminium multiport tube. Local condensation heat transfer measurements with such a multi-microchannel test section are very challenging due to the large uncertainties related to the heat flux estimation. Presently, a new experimental test facility was designed with a test section to directly measure the wall temperature along a vertically aligned aluminium multiport tube with rectangular channels of 1.45 mm hydraulic diameter. Then, a new data reduction process was developed to compute the local condensation heat transfer coefficients accounting for the non-uniform distribution of the local heat flux along the channels. The condensation heat transfer coefficients showed the expected decrease as the vapour quality decreased (1.0-0.0) during the condensation process, as the mass velocity decreased and as the saturation temperature increased. However, the heat transfer coefficients were not affected by the condensing heat flux or by the entrance conditions within the tested range. It was found that the heat transfer performance of R1234ze(E) was about 15-25% lower than for R134a but relatively similar to R236fa. The experimental data were then compared with leading prediction methods from the literature for horizontal channels. In general, the agreement was poor, over-predicting the high Nusselt number data and under-predicting the low Nusselt number data, but capturing the mid-range quite well. A modified correlation was developed and yielded a good agreement with the current database for all three fluids over a wide range of operating conditions.

Détails

  • Titre original : Experimental study on condensation heat transfer in vertical minichannels for new refrigerant R1234ze(E) versus R134a and R236fa.
  • Identifiant de la fiche : 2011-0095
  • Langues : Anglais
  • Source : Exp. therm. Fluid Sci. - vol. 35 - n. 3
  • Date d'édition : 04/2011
  • DOI : http://dx.doi.org/10.1016/j.expthermflusci.2010.11.006

Liens


Voir la source

Indexation